Detcon SmartWireless CXT User Manual

SmartWireless® CXTMobile Gas Detection SystemWith DisplayOperator’s Installation and Instruction ManualDETCON, Inc.4055 Technology Forest Blvd.,The Wo

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 6 of 42Figure 3 SmartWireless® CXT Radio Module1.7 Sensor InputsThe SmartWireless® CXT inclu

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 7 of 42The four sensor input lines are fused at the PC board level for safety purposes. Thes

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 8 of 42If the Smart Wireless® CXT is ordered with the Relay PCA option, the Relay PCA can be

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 9 of 42Relay PCANCCOMNOFAULTNCCOMNOALARM 3NCCOMNOALARM 2NCCOMNOALARM 1EnclosureALARM 2 (Gree

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 10 of 42GND (Black) 2+24VDC (White) 3Chassis GND (Green) 1Pin 1Pin 2Pin 3Figure 9 Power Conn

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 11 of 42CAUTION2. Safety Guidelines for Safe UseIf equipment is used in a manner not specifi

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 12 of 42WarningAll Turck cable connectors have dust/water sealing caps that are mandatory to

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 13 of 423. Installation3.1 Initial SetupThe Detcon tripod (P/N 975-TRIPOD-100) provides a st

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 14 of 42Pipe Mounting U-Boltsand hardwareTripod Center Pipe12"3.5"4.5"10.25&q

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 15 of 426. The CXT Sensor can also be wall-mounted using the four holes provided in the moun

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 iiThis page left intentionally blankShipping Address: 4055 Technology Forest Blvd., The Woodlands

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 16 of 42Battery Installation9. Loosen the screws holding the door panel in place, and swing

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 17 of 4211. Remove the 6-32 screws and washers holding the battery bracket is place, and rem

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 18 of 4213. Position the battery bracket (and battery) with the connector on the left side,

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 19 of 424. Recharging the Internal Battery Pack4.1 Non-Hazardous and Indoor LocationAt a saf

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 20 of 425. System Configuration5.1 System OperationThe setup of the controller is critical f

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 21 of 42This switch moves the user up the Main Menu flow chart. It is also used to change se

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 22 of 42 DC POWER = Communicating; line powered. BATT ERR = Communicating; cannot read sma

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 23 of 42MAIN DISPLAYNORMAL OPERATIONUTILITY MENUSET RF SILENCEAND RF SLEEPUTILITY MENUSET CO

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 24 of 424. Swipe the ENTER marker to initiate the search. The CXT controller will perform an

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 25 of 423. If there is more than one channel, a swipe of the down arrow marker while the fla

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 iiiTable of Contents1. Introduction...

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 26 of 42 Latching or Non-Latching Energized or De-Energized Silenceable or Non-Silenceabl

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 27 of 42Upon entering this menu, the SmartWireless® CXT controller will automatically initia

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 28 of 429. Swipe the magnet over the markers of the up or down arrows to move the arrow prom

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 29 of 426. Maintenance and Service Personnel ActivitiesNOTEOnly service or maintenance relat

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 30 of 426.3 Replacement of Condensation Prevention PacketOn an annual or bi-annual basis, th

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 31 of 42The fourth protective measure is to follow these instructions properly and secure th

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 32 of 427. Troubleshooting GuideSensor COMM Error Verify all devices are set to the same RF

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 33 of 428. Customer Support and Service PolicyDetcon HeadquartersShipping Address: 4055 Tech

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 34 of 429. Warranty NoticeDetcon Inc. warrants the SmartWireless® CXT System to be free from

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 35 of 4210. Appendix10.1SpecificationsSystem SpecificationsCapacity: 32 I/O ChannelsSensor I

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 iv10.2.2 Set RF Silence and RF Sleep...

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 36 of 4210.2UtilitiesCAUTIONContact a Detcon representative prior to changing any settings i

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 37 of 42NOTEThe SLAVE ID is the Modbus™ address in hex of the sensor or device being assigne

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 38 of 422. A swipe of the up arrow marker while the flashing cursor is on SENSOR TYPE will r

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 39 of 42The recommended value for the TTE should be five days and applies to all battery pow

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 40 of 42The Set COMM Baud Rates menu displays the current baud rate settings for COMM1 (mast

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 41 of 422. These values can be changed by swiping the magnet over the markers of the up or d

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 42 of 4210.4Revision LogRevision Date Changes made Approval1.0 3/28/13 Release LBU1.1 10/30/

21.25Typ. 3.5 11.25 10.25 12 4.34 PipeMountingHardwareNOTE:Unit shown has the max options:Reset SwitchPower Input Port4 sensor portsStrobeHornExt

StrobeAntenna4-20 mA PCAand Alarm PCANOTE:Unit shown has the max options:Reset SwitchPower Input Port4 sensor portsStrobeHornExternal Alarm PortRXT-32

RF toAntenna(Mounted under the Relay PCA)4-20mA PCA+_NOTES:'Wet' Alarm wiring shown.Wiring for complete unit shown. * Note: Components su

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 1 of 421. Introduction1.1 FeaturesThe Detcon SmartWireless® CXT controller (Figure 1) is a m

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 2 of 42 alarm stations and gas detection sensors.SmartWireless® CXT ControllerThe Detcon S

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 3 of 42Figure 2 provides a complete systematic description of the CXT Controller System with

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 4 of 42SilenceableThe corresponding alarm LED and relay can be deactivated by acknowledging

Sentinel CXTSentinel CXT Instruction Manual Rev. 1.5 Page 5 of 42NOTE 1No other Battery Charger or VDC input power source may be used with this CXTCon